A Tale of Two PS2 Slims - Faulty Retro Console Restoration
In this video I repair two PS2 Slims, which are part of a set of four that I purchased during a recent faulty console lot. This is a pair of SCPH-75001 PS2 Slims, both of which do not read disks. In fact, when a disk is inserted in the drive, there is no indication that the disk is spinning or that the laser is moving. The drives appear dead on both units.
One of the units is a virgin PS2 Slim with an intact warranty seal. The other has been opened and worked on previously, made obvious by the missing screw covers, mismatched screws, and electrical tape instead of rubber feet on the bottom of the unit. Never a promising sign when working on an "untested" system, but figured I'd give it my best shot.
I started with the worst of the two systems, given it's my first time working on a PS2 and I'd rather learn on the worst of the two units. I do a full tear-down and test all the fuses, none of which are blown. Upon closely inspecting the lid sensor (there are two lid sensors on a PS2 Slim) I discovered that the front door sensor was intermittent. A shower with some contact cleaner seemed to bring it back to proper operation.
To my surprise (and delight) the second PS2 Slim had the exact same issue, with the exact same lid sensor. What are the odds! It goes to show that this is a function of poor design, and electronics tend to have common points of failure most of the time, rather than unique and fringe complex failures (happens but less often). Further testing showed that the previous owner of one of the units had improperly adjusted the drive potentiometers, which when correctly set, resolved all the playback issues the unit was having.
This was a fun (but lengthy) repair. I underestimated the effort it took to fix two systems at the same time (even though they ended up having the same issue) while recording decent footage to take you folks along for the side. No double repairs in the near future!
🎵 Music
Bensound - Dreams
https://www.bensound.com
Support by RFM - NCM: https://bit.ly/2xGHypM
Affiliated links below to some of the tools I use if you'd like to support the channel:
🖥 Composite and S-Video on my Mac
USB Capture Card: https://amzn.to/2YM4TT7
(Catalina 64-bit drivers can be found on the manufacturer's website)
🔧 Toolkit
Screwdriver Set: https://amzn.to/2X7s0Gj
Automatic Wire Stripper: https://amzn.to/30F5TJm
White Lithium Grease: https://amzn.to/2UApx5M
🖌 Soldering Essentials
TS100 Soldering Iron: https://amzn.to/2YIJZUR
No Clean Flux Syringe: https://amzn.to/2NFUZvQ
No Clean Solder: https://amzn.to/2NHEAqQ
Desoldering Braid: https://amzn.to/312Grws
🔍 Soldering Add-ons
Tip Tinner: https://amzn.to/31w2EF4
Helping Hands Soldering Aid: https://amzn.to/3ihgksP
Heat Shrink Tubing: https://amzn.to/31wGq4b
Heat Gun: https://amzn.to/3hsXKgi
🔥 Thermal Compounds
Arctic MX-4 Thermal Paste: https://amzn.to/2Ak2y8w
1.5MM Arctic Thermal Pads: https://amzn.to/2Vv1RQU
Видео A Tale of Two PS2 Slims - Faulty Retro Console Restoration канала Borderline OCD
One of the units is a virgin PS2 Slim with an intact warranty seal. The other has been opened and worked on previously, made obvious by the missing screw covers, mismatched screws, and electrical tape instead of rubber feet on the bottom of the unit. Never a promising sign when working on an "untested" system, but figured I'd give it my best shot.
I started with the worst of the two systems, given it's my first time working on a PS2 and I'd rather learn on the worst of the two units. I do a full tear-down and test all the fuses, none of which are blown. Upon closely inspecting the lid sensor (there are two lid sensors on a PS2 Slim) I discovered that the front door sensor was intermittent. A shower with some contact cleaner seemed to bring it back to proper operation.
To my surprise (and delight) the second PS2 Slim had the exact same issue, with the exact same lid sensor. What are the odds! It goes to show that this is a function of poor design, and electronics tend to have common points of failure most of the time, rather than unique and fringe complex failures (happens but less often). Further testing showed that the previous owner of one of the units had improperly adjusted the drive potentiometers, which when correctly set, resolved all the playback issues the unit was having.
This was a fun (but lengthy) repair. I underestimated the effort it took to fix two systems at the same time (even though they ended up having the same issue) while recording decent footage to take you folks along for the side. No double repairs in the near future!
🎵 Music
Bensound - Dreams
https://www.bensound.com
Support by RFM - NCM: https://bit.ly/2xGHypM
Affiliated links below to some of the tools I use if you'd like to support the channel:
🖥 Composite and S-Video on my Mac
USB Capture Card: https://amzn.to/2YM4TT7
(Catalina 64-bit drivers can be found on the manufacturer's website)
🔧 Toolkit
Screwdriver Set: https://amzn.to/2X7s0Gj
Automatic Wire Stripper: https://amzn.to/30F5TJm
White Lithium Grease: https://amzn.to/2UApx5M
🖌 Soldering Essentials
TS100 Soldering Iron: https://amzn.to/2YIJZUR
No Clean Flux Syringe: https://amzn.to/2NFUZvQ
No Clean Solder: https://amzn.to/2NHEAqQ
Desoldering Braid: https://amzn.to/312Grws
🔍 Soldering Add-ons
Tip Tinner: https://amzn.to/31w2EF4
Helping Hands Soldering Aid: https://amzn.to/3ihgksP
Heat Shrink Tubing: https://amzn.to/31wGq4b
Heat Gun: https://amzn.to/3hsXKgi
🔥 Thermal Compounds
Arctic MX-4 Thermal Paste: https://amzn.to/2Ak2y8w
1.5MM Arctic Thermal Pads: https://amzn.to/2Vv1RQU
Видео A Tale of Two PS2 Slims - Faulty Retro Console Restoration канала Borderline OCD
Показать
Комментарии отсутствуют
Информация о видео
Другие видео канала
Sony PlayStation Disc Skipping Issues - Retro Console RepairRed Dot of Death - Xbox 360 S Southbridge ReflowXbox 360 Red Ring of Death - DIY GPU ReflowRestoration original PlayStation (PS1) - Retro Console Restore & RepairBroken "Fat" PS2 from eBay (Not So Broken) - Retro Console RestorationPS2 Slim Custom Mod - Game ConsoleTransformation200GB Sega Dreamcast Mod - Retro Console RestorationSNK Neo Geo AES BIOS Mod Japan to USA - Repair-a-thon Ep. 2 - Retro Console RestorationXbox Trace Repair & Modchip - Retro Console RepairRestoration old broken original PlayStation PS2 console – Vintage Retro Console Restoration & RepairI Bought a PALLET of BROKEN PS4's - How Many Can I Fix?Xbox Corroded Traces & DVD Surgery (Part 1) - Retro Console RestorationFilthy PS4 Restoration & Repair - $45 GumTree buyI restored this $7 Junk Playstation 2 Slim - Retro Console Restoration & RepairModded Xbox 1TB Hard Drive Upgrade - Retro Console Repair$0.96 Faulty PSone Repair - Retro Console RestorationDESTROYED Nintendo NES Restoration and RepairXbox 360 Custom Mod - Game console restorationApple iBook G3 "Clamshell" Power Issues - Retro Computer RepairSega Genesis Bad Controller Ports - Retro Console Restoration