Ford 3.5L and 3.7L Water Pump Leak/ What To Look For
In this video I explain how a lot of Ford 3.5L V-6 and 3.7L V-6 water pumps leak. This water pump design can be found on a number of Ford products that come with the 3.5L V-6 and 3.7L V-6. The particular vehicle featured in the video is a 2007 Ford Edge equipped with a 3.5L. This water pump design can not only be found in the Ford Edge but also the Ford Taurus and and Explorer ( and I failed to mention the Ford Flex) that come equipped with the 3.5L engine or the 3.7L engine. This water pump designed was used for many years from roughly 2007-2018. (maybe longer) There may be slight variations in design from year to year but the concept of how the water pump leaks is the same between the years. The water pump is timing chain driven which means that it is located inside the engine behind the timing cover. A lot of vehicles out there that have an externally mounted water pump, unlike the Ford 3.5L and 3.7L mentioned above, are equipped with a weep hole that allows coolant to leak directly from the water pump. But, because this water pump on the 3.5L and 3.7L is located in the engine it can't leak like a normal water pump. The coolant has to be channeled outside the engine so that the coolant does not leak into the engine oil. In this video I explain the design of this weep hole and how coolant is channeled out the side of the engine block through a special passage. I also, show it to you.
Now, while it is typical for this water pump to leak from the weep hole, they can also leak into the engine due to catastrophic failure. The vehicle featured in the video has this problem and I explain how coolant got into the engine oil and mixed with it. (It's bad news). The bearing inside the water pump went out and caused play to develop on the shaft where the pulley mounts. The coolant leaked right through this.
Note: This is just two ways in which this water pump can leak. I suppose the gasket could also leak but I've not seen that yet. The two ways mentioned in the video are usually how this water pump fails. (in my experience)
Also, This is not 3.5L V-6 Ecoboost used in a lot of late model Ford F-150s. (check your manual to see if the information in the video applies.) If you notice that your engine has a water pump that is externally mounted then this video does not apply to your vehicle. Just take a look and make sure. I think I'm pretty accurate with the list of vehicles and engine sizes mentioned above that have this type of water pump. However, you need to check me. Make sure. Verify that the vehicle you are working on is similar to the ones mentioned in the video. A repair manual is a must to be sure of this.
At about the 2:11 mark I mention the freeze plug is not available. Well, its not actually a freeze plug. It looks similar to one, but it's actually just a plug that goes into the weep hole to restrict the weep hole. It doesn't totally block it, it just restricts it. I don't know if that part is available. That being said you don't need one, unless you took it out.
Here is a link to a video describing the diagnostic process I went through to figure this out.
https://youtu.be/pZyM3m-OEuI
Here is a link to part 1 of a video showing the replacement of the water pump and timing chain:
https://youtu.be/bBgsUS1awr8
I thought it was interesting that Scotty Kilmer discussed this in a video he uploaded as I was putting this video together. Here is the linke to the video. Take a look. He talks about it for the first 1.5 minutes.
https://youtu.be/U9r-dV5Zc6A
DISCLAIMER
Barbour's Auto Help is not responsible for any damage or personal injury incurred in the process of performing any auto repairs done by you the viewer. Automotive repair is extremely dangerous. Repair your vehicle at your own risk. It is the viewers responsibility to verify all information and procedures as outlined in YOUR REPAIR MANUAL AND OWNERS MANUAL FOR YOUR VEHICLE. Owning and using a repair manual suited for your vehicle is essential for correctly and safely performing ANY repair to your vehicle. Always wear safety glasses and heed all instructions for use applicable to any piece of equipment you may use. Due to circumstances out of the control of Barbours Auto Help, Barbours Auto Help makes no guarantee that by the use of the information given in this video a quality repair will be made. Barbour'sAutoHelp makes no guarantee that the information provided is totally complete, syncronized and accurate. Verify everything using an appropriate repair manual.
Repair your vehicle at your own risk! Barbour's auto help does not guarantee a proper repair using these techniques.
Видео Ford 3.5L and 3.7L Water Pump Leak/ What To Look For канала Barbour's Auto Help
Now, while it is typical for this water pump to leak from the weep hole, they can also leak into the engine due to catastrophic failure. The vehicle featured in the video has this problem and I explain how coolant got into the engine oil and mixed with it. (It's bad news). The bearing inside the water pump went out and caused play to develop on the shaft where the pulley mounts. The coolant leaked right through this.
Note: This is just two ways in which this water pump can leak. I suppose the gasket could also leak but I've not seen that yet. The two ways mentioned in the video are usually how this water pump fails. (in my experience)
Also, This is not 3.5L V-6 Ecoboost used in a lot of late model Ford F-150s. (check your manual to see if the information in the video applies.) If you notice that your engine has a water pump that is externally mounted then this video does not apply to your vehicle. Just take a look and make sure. I think I'm pretty accurate with the list of vehicles and engine sizes mentioned above that have this type of water pump. However, you need to check me. Make sure. Verify that the vehicle you are working on is similar to the ones mentioned in the video. A repair manual is a must to be sure of this.
At about the 2:11 mark I mention the freeze plug is not available. Well, its not actually a freeze plug. It looks similar to one, but it's actually just a plug that goes into the weep hole to restrict the weep hole. It doesn't totally block it, it just restricts it. I don't know if that part is available. That being said you don't need one, unless you took it out.
Here is a link to a video describing the diagnostic process I went through to figure this out.
https://youtu.be/pZyM3m-OEuI
Here is a link to part 1 of a video showing the replacement of the water pump and timing chain:
https://youtu.be/bBgsUS1awr8
I thought it was interesting that Scotty Kilmer discussed this in a video he uploaded as I was putting this video together. Here is the linke to the video. Take a look. He talks about it for the first 1.5 minutes.
https://youtu.be/U9r-dV5Zc6A
DISCLAIMER
Barbour's Auto Help is not responsible for any damage or personal injury incurred in the process of performing any auto repairs done by you the viewer. Automotive repair is extremely dangerous. Repair your vehicle at your own risk. It is the viewers responsibility to verify all information and procedures as outlined in YOUR REPAIR MANUAL AND OWNERS MANUAL FOR YOUR VEHICLE. Owning and using a repair manual suited for your vehicle is essential for correctly and safely performing ANY repair to your vehicle. Always wear safety glasses and heed all instructions for use applicable to any piece of equipment you may use. Due to circumstances out of the control of Barbours Auto Help, Barbours Auto Help makes no guarantee that by the use of the information given in this video a quality repair will be made. Barbour'sAutoHelp makes no guarantee that the information provided is totally complete, syncronized and accurate. Verify everything using an appropriate repair manual.
Repair your vehicle at your own risk! Barbour's auto help does not guarantee a proper repair using these techniques.
Видео Ford 3.5L and 3.7L Water Pump Leak/ What To Look For канала Barbour's Auto Help
Показать
Комментарии отсутствуют
Информация о видео
Другие видео канала
![Ford 3.5L 3.7L Duratec V6 Chain Driven Water Pump Failures: Check it Before it Destroys Your Engine!](https://i.ytimg.com/vi/R3-NOGZL8ms/default.jpg)
![My secret on how I avoid water pump failure on my Ford Edge](https://i.ytimg.com/vi/W6voO1uD0a4/default.jpg)
![2010 Ford Taurus Leak Diagnostic Water Pump (Coolant Weep Hole)](https://i.ytimg.com/vi/7q4-AAt1vX0/default.jpg)
![MOST COMMON COOLANT LEAK LEAKS FORD 3.5 V6 FORD EDGE TAURUS FLEX FUSION LINCOLN MKX MKZ](https://i.ytimg.com/vi/S1op5M_Yrgs/default.jpg)
![The One Fatal Design Flaw With Ford's 3.5L & 3.7L Duratec Engines](https://i.ytimg.com/vi/xvUr_k4j9gc/default.jpg)
![Cloyes Timing Chain System Installation on Ford 3.5-liter and 3.7-liter DOHC V6 Engine](https://i.ytimg.com/vi/0Bs9yrm4c6E/default.jpg)
![3.5L Explorer Water Pump](https://i.ytimg.com/vi/ZlDjrLYA1Xw/default.jpg)
![Ford F-150 3.5l Ecoboost Water Pump & Thermostat Replacement (Complete Guide)](https://i.ytimg.com/vi/QfO5hFN1NHw/default.jpg)
![How To Replace A Waterpump On A 2014 Ford Mustang 3.7L](https://i.ytimg.com/vi/qpzuR2Os4uU/default.jpg)
![Wiley Motorsports SP: Ford 3.5/3.7L Duratec V6 engine problems](https://i.ytimg.com/vi/gUiExAz06ks/default.jpg)
![Part 1 Ford Flex oil leak, coolant loss, P0016 water pump replacement](https://i.ytimg.com/vi/VjMgagyP0SI/default.jpg)
![How I Diagnosed Faulty Water Pump 07 Ford Edge 3.5L](https://i.ytimg.com/vi/pZyM3m-OEuI/default.jpg)
![Ford Mustang / F150 / Transit 250 3.7L V6 Water Pump Replacement](https://i.ytimg.com/vi/rtK6rpCExmA/default.jpg)
![A Serious Warning to All Ford, Subaru, and Nissan Owners (This Fatal Flaw Can Destroy Your Engine)](https://i.ytimg.com/vi/fYWGA_zBulo/default.jpg)
![Ford's BAD Water Pump Problem - Ep. 5.451](https://i.ytimg.com/vi/PdZhljNSTVg/default.jpg)
![Primary Timing Chain and Water Pump Replacement 07 Ford Edge 3.5L Part 2](https://i.ytimg.com/vi/o4npM0waXmY/default.jpg)
![WHY IT COST $1500 TO REPLACE WATER PUMP ON FORD, LINCOLN, MAZDA 3.5 3.7 ENGINE EDGE FLEX TAURUS MKX](https://i.ytimg.com/vi/GTaLmZj0w8E/default.jpg)
![replace timing chain and water pump ford explorer 2016 3.5 v6 location replacement explained](https://i.ytimg.com/vi/u1PE3ojZkDg/default.jpg)
![Why does the Ford Taurus, Explorer, Edge 3.5L water pump cost over $1400?](https://i.ytimg.com/vi/qMiSc8epmn0/default.jpg)
![Ford F150 3.5L ECOBOOST Bad Engine Teardown! What Will I Find That Failed?](https://i.ytimg.com/vi/UN3cjU3o0G4/default.jpg)